Keahuolu deep well back online

KAILUA-KONA — North Kona is now only short two water sources after the county Department of Water Supply completed “top-side” repairs on the Keahuolu deep well, the department said in an email Monday.

Keahuolu most recently fell out of commission in the second week of October 2017 after being repaired in late January last year.

ADVERTISING

DWS brought Keahuolu back online Friday, said DWS spokesperson Kaiulani Matsumoto, but the 10 percent voluntary water conservation in North Kona remains in effect until further notice.

The success at Keahuolu leaves deep wells at Hualalai and Waiaha as the only remaining downed wells. As many as five of the North Kona system’s 13 water sources were simultaneously inoperative at points last year.

There is movement at both remaining offline wells, starting with Hualalai, where Matsumoto said DWS is planning to implement a change of design. Hualalai was brought back online in early October, failing only a few days later and prompting DWS officials to consider the likelihood of problems beyond premature failure of the deep well’s pump and/or motor.

In an informational sheet available on its website, DWS noted a repair bid is underway and that it set a scheduled bid opening date of Feb. 15 for the rights to “install a slim-line pump and motor assembly with a shroud” at Hualalai.

According to ESP Completion Technologies at espctllc.com, motor shroud systems employ a shroud that creates a seal from above the pump intake to the motor’s base, which only allows for fluid to enter from the bottom of the shroud. The website says it can reduce failures brought about by overheating.

There is no concrete time line for Hualalai’s return to service beyond the bid opening date.

The problem at Waiaha is not as clear as DWS can’t evaluate until the pump and motor accidentally dropped in the well during a botched extraction are fished out. According to the DWS website, the contractor, Derrick’s Well Drilling and Pump Services LLC, will begin work to pull the equipment up in early February.

ADVERTISING

“If removal is successful, the well will need to be inspected for any damages,” the information sheet reads. “The pump, motor, column pipe and power cable will need to be replaced to prevent an unknown weakened component causing a failure in the future.”

Email Max Dible at mdible@westhawaiitoday.com.